桥丝式电火工品静电感度测试方法研究

本文对目前静电感度试验的现状进行了分析。在理论分析的基础上解决了JGY-50型静电火花感度仪的串联电阻和真空开关所带来的问题。提出了桥丝式电火工品的静电感度测试新方法,通过一个高压线性采样装置直接测量试样在试验过程中的电压、电流曲线,求得试样实际消耗的能量,以此统计试样的静电感度。采用这种方法,测试了JD-11电点火具的50％发火能与放电时间常数的关系,得到了呈单调规律变化的曲线。     

电发火系统感应电流测试方法研究

对电发火系统在电磁环境下的感应电流测量采用一种新型的白光干涉型光纤测温仪。通过测量电发火系统中电火工品桥丝在电磁环境下温度的变化,利用桥丝温度和感应电流的关系,测量出桥丝上的感应电流,进而对弹箭系统进行电磁环境效应评估。     

灼热桥丝式电火工品静电发火数理模型

根据灼热桥丝式电火工品的电热起爆机理,在桥丝药剂系统的物理传热过程中忽略桥丝药剂接触面的热阻和热容等假设条件下,建立其静电发火的理想数理模型。针对此模型方程提出了一种数值解法,并对解的结果进行了讨论。     

电桥材料和结构对发火感度影响分析

电桥材料和结构可影响电火工品的发火感度,依据电火工品发火能量平衡方程,对几种常用材料不同电桥形状对电火工品(EED)感度的影响进行了分析,结果表明通过改变电桥材料和电桥结构能够降低EED的发火感度,为EED改进提供了依据。     

火箭弹防静电作用研究

针对电发火弹药静电放电问题,以某型130 mm火箭弹为例,采用真实静电感度测试系统测试了电火工品在有、无绝缘层时50%的静电点火能量,并在试验程序及数据处理中使用真实静电感度数据处理方法统计了50%静电发火能量的估计值。通过比较发现二者的差值在误差范围内,这表明静电放电研究中可以将弹体所接受的能量视作全部作用于火工品上,绝缘层不吸收静电放电的能量。在电发火弹药的防护中,必须采用静电防护措施杜绝电发火弹药的意外发火。     

表面粗糙度对产品质量影响的一例——08引信瞎火原因分析

1992年我厂研制的08引信在国家靶场进行设计定型试验时,174发引信发火性试验,仅有一发引信瞎火,其发火率相当高,从而通过了设计定型。但是,在1994年生产定型的通关批制造过程中,该引信的质量出现了异常,引信瞎火率高达50%以上。为寻找引信瞎火原因,工厂组织了大量人力对所有零件的所有     

红外脉冲强光辐射源中电爆丝爆炸机理研究

利用电爆丝的一种红外脉冲强光辐射新技术,从理论和实验上研究了电爆丝的爆炸机理。用电爆丝绝热加热模型数值模拟了电爆丝在冲击大电流作用下的电爆炸特性,电爆丝根数对电爆炸特性的影响。实验结果与理论模拟相一致。     

电火工品发火信号波形采样研究

针对采样频率选取不当使采集的电火工品发火信号波形失真问题,研究了在实际采样过程中采样频率的取值方法。首先根据发火信号的特征,设计了采样方案;然后利用虚拟仪器软件对发火信号进行频谱分析,确定合适的采样频率和采样点数,进而采集完整的信号波形;最后结合试验数据对采样频率的选取进行了分析,得出了在实际采样过程中采样频率的取值规律。     

平行双线式电火工品感应电流仿真研究

根据Agrawal理论,建立平行双线式电火工品的传输线模型,通过仿真计算分析外界电磁场和电火工品各物理参数对负载端感应电流大小的影响,为电火工品的射频安全性研究提供一定的参考．     

惰性气体中电爆丝爆炸激励冲击波的理论分析

建立了惰性气体中电爆丝爆炸激励的冲击波模型。对于冲击波马赫数与光辐射强度的关系、惰性气体种类对冲击波强度的影响以及电爆丝根数对冲击波强度的影响,进行了理论计算与分析,所得结论对红外脉冲强光辐射源的研究有重要作用。     

Effects of module number and firing condition on charge thermal safety in gun chamber

Thermal safety of modular charge which is fed into and retained in the chamber after gun fires consecutively is first investigated with cook-off method.A two-dimensional cook-off model of modular charge in gun chamber is established and the cook-off process of modular charge in gun chamber is numerically simulated.Then the effects of module number and firing condition on charge thermal safety are evaluated by researching the cook-off response characteristics of modules.The results show that,under conditions of different module numbers the cook-off responses all occur on the module closest to the boundary of missile,and the single-base propellants located at the inner surface of cartridge ignite first.When the number of loaded module changes from 1 to 6,the cook-off response temperatures vary little,only in a small range of 478.1 K-482.4 K.The cook-off response times decrease logarithmically in the range of 211.2 s-166.7 s with the increasing length of residual air gap in gun chamber.The simulation results are well matched with the experimental data.Furthermore,different firing conditions have great influence on the cook-off response time,minor influence on the initial response position and little in-fluence on the response temperature.Under the three conditions of consecutive 32 launches with 5 rounds/min,43 launches with 1 round/min,and 41 launches with different firing frequencies,the cook-off response temperatures are 479.2 K,481.1 K and 479.9 K respectively and the response times are 709.2 s,211.2 s and 214.4 s respectively.The response position is near the middle area of the inner cartridge surface in the former condition and near the right area in the latter two conditions.     

公共娱乐场所电气火灾成因分析和预防对策

公共娱乐场所在利用大量电气设备、设施为人们提供舒适环境的同时,也增大了电气火灾发生的危险性。分析了公共娱乐场所电气火灾的特点及成因,提出了预防公共娱乐场所电气火灾的消防安全管理对策。     

析健全灭火救援勤务实战化的必要性

随着科技水平的不断提高，各类建筑、交通运输、化工类产品的发展和运用，消防官兵在灭火救援工作中因爆炸、触电、倒塌、辐射等种种原因而造成伤亡的事故呈直线上升趋势，这当中有许多客观因素，但这和消防部队指挥员指挥水平也有很大关系。灭火救援潜在危险因素增多，当前建立健全勤务实战化，提高灭火救援能力很有必要。     

Experimental investigation of a cook-off temperature in a hot barrel

The experimental investigations of the effect of contact time/temperature on initiating the cook-off using 7.62 mm calibre cartridge cases (CC) were conducted previously. These cartridges were filled with commercial off-the-shelf (COTS) double based (DB) propellant (Bulls Eye) and were loaded in a hot chamber. The thermal explosion temperature is of great significance to both weapon designers and safety inspectors as it provides the operational limit and safe operating temperature. For CC under test, it was found that the cook-off temperatures of this propellant were encountered with the heat transfer profile of the simulated gun barrel between 151.4 °C and 153.4 °C, with a reaction occurring in less than 300 s after the round was chambered. Usefully, each experiment was found to be consistent and repeatable.     

电热毯火灾模拟与微观形貌分析方法研究

通过模拟电热毯在各种条件下工作并引起火灾的过程,制备出不同形貌特征的电热丝,然后分别用体式显微镜和扫描电子显微镜观察电热丝表面的宏观和微观形貌,通过比较和分析其火灾痕迹特征,鉴别出电热毯在火灾发生前的工作状态,为电热器具火灾原因的准确认定提供依据,并提出一种新的鉴定技术——微观形貌法。     

Thermal hazard assessment of TKX-50-based melt-cast explosive

In the present study, thermal hazards of TNT and DNAN used as the molten binder in TKX-50-based melt-cast explosives were comparatively studied through accelerating rate calorimeter (ARC) and Cook-off experiments. Two kinds of ARC operation modes were performed to investigate the thermal safety performance under adiabatic conditions (HWS mode) and constant heating (CHR mode). The obtained results demonstrated that at both heating modes, DNAN/TKX-50 outperformed TNT/TKX-50 from the thermal safety point of view. However, the sensitivity to heat of the samples was reverse because of the different heating modes. In addition, the results of thermal hazard assessment obtained from the cook-off experiment complied with ARC analysis which indicated the molten binder TNT replaced by DNAN would reduce the hazard of the TKX-50 melt cast explosive. Furthermore, the results of cook-off experiments also showed that DNAN/TKX-50 outperformed TNT/TKX-50 from the aspect of thermal stability, which was consistent with the result of CHR mode because of the similar heating process.     

红外技术及其在消防领域中的应用

介绍红外技术及其在消防领域中的应用,其应用主要包括电气防火检查、火灾探测、火情侦察和灭火救援等方面.     

船舶火灾特性及其预防对策

随着国际贸易不断增多,作为运输重要手段的航运业也呈现迅猛发展态势,与此同时各类船舶火灾事故的数量和财产损失也在不断攀升。这些火灾主要呈现出火灾荷载量较大,蔓延速度快,电气线路复杂,线路铺设混乱,散热、排烟困难,监管盲区较多,人员消防安全意识淡薄等特性。要有效防控船舶火灾,需要加强船员消防安全培训和船舶消防设施的建设,强化船舶消防安全监管和建立＂人、物、机＂一体的火灾监控体系。     

电气火灾统计分析研究

通过对比分析近10年来的火灾统计数据,找出了近几年我国电气火灾发生和发展的特点及规律.根据电气火灾原因分布规律,发现电气线路火灾在电气火灾中占有最大比例;根据电线电缆火灾原因统计数据,分析出发生的电线电缆火灾中,外因引发重大火灾的概率和数量更大.     

红外线式电暖器热辐射引起火灾的研究

本文从理论上阐明了红外线式电暖器引燃可燃物的可能性,通过对普通家具材料的热辐射试验,获取了影响这种引燃的条件和现场残留痕迹物证的特征。这对于安全使用电暖器及其引起火灾原因的调查有着重要的意义。